Toyota Land Cruiser

FJ60, FJ62 and FJ80 1980-1997 of release

Repair and car operation



Toyota Land Cruiser
+ 1. The maintenance instruction
+ 2. Maintenance service
+ 3. Engines
+ 4. Systems of cooling, heating
+ 5. Fuel and exhaust systems
+ 6. System of decrease in toxicity
+ 7. Transmission
- 8. Brake system
   8.1. Technical characteristics
   - 8.2. ABS-system
      8.2.1. ABS-system units
      8.2.2. Diagnostics and ABS-system repair
   8.3. Колодки disk brakes (forward or back)
   8.4. A brake support
   8.5. A brake disk
   8.6. Колодки drum-type brakes
   8.7. The wheel cylinder of brakes
   8.8. The main cylinder of brakes
   8.9. Hoses and hydrodrive tubes
   8.10. Removal of air from a hydrodrive of brakes
   8.11. The vacuum amplifier of brakes
   8.12. Колодки a manual brake of back disk brakes
   8.13. Adjustment of a manual brake
   8.14. A cable of a manual brake
   8.15. The switch of a signal of braking
   8.16. A regulator of pressure of back brakes (dosing out and перепускной the valve)
+ 9. Suspension brackets and a steering
+ 10. A body
+ 11. An electric equipment
+ 12. Electroschemes



8.2.2. Diagnostics and ABS-system repair
THE GENERAL DATA

At ignition inclusion the control lamp of system ABS lights up, and after engine start-up dies away. If the lamp continues to burn, in system ABS malfunction is registered.
The prevention

The control lamp of system ABS can continue to burn if the lever of a distributing box is translated in position LOW (the interaxal differential is included) as the system is disconnected.


PERFORMANCE ORDER
1. For access to codes of refusals include ignition (the engine not to start), перемкните conclusions Е1 and the Hardware of a socket of the channel of the data and get a plug from nests WA and WB (1 – a crosspiece, 2 – a plug). The lever of a distributing box should be translated in position 2WD.
2. Figures of a two-place code are defined on number of blinkings of the control lamp divided by a pause in 1,5 сек (for example, a code 34 – 3 flashes, a pause 1,5 сек and 4 flashes).
3. The following code appears through 2,5 сек after the first. If the system is serviceable, the lamp blinks with frequency of 2 Hz.
4. Character of refusal define under the table.
5. After reading erase codes for what press a pedal not less than 8 times for 3 seconds
6. Remove a crosspiece and put into place a plug.
7. Hand over the car in car-care centre.

Code
Character of malfunction
Undertaken actions
11
Breakage in a chain of the relay of the solenoid
To check up the relay of the solenoid and conducting of a chain of the relay
12
Short circuit of a chain of the relay of the solenoid
The same
13
Breakage in a chain of the relay of the relay of the electric motor of the pump
To check up the relay of the pump and conducting of a chain of the relay
14
Short circuit of a chain of the relay of the electric motor of the pump
The same
21
The chain of the solenoid of the right forward wheel is faulty
To check up the solenoid актюатора and a solenoid socket
22
The chain of the solenoid of the left forward wheel is faulty
The same
23
The chain of the solenoid of a back wheel is faulty
The same
31
The gauge of speed of the right forward wheel is faulty
To check up gauges of speed, conducting and a gauge socket
31
The gauge of speed of the right forward wheel is faulty
To check up gauges of speed, conducting and a gauge socket
32
The gauge of speed of the left forward wheel is faulty
The same
33
The gauge of speed of the right back wheel is faulty
The same
34
The gauge of speed of the left back wheel is faulty
The same
35
Breakage in a chain of the gauge of speed of the left forward or right back wheel
The same
36
Breakage in a chain of the gauge of speed of the right forward or left back wheel
The same
41
The delay gauge is faulty
Check up the gauge, gauge installation, conducting and a gauge socket
42
The chain of the gauge of delay is faulty
The same
48
The chain of interaxal differential is faulty
Check up blocking of interaxal differential, the blocking switch, a control lamp and conducting
51
The electric motor актюатора or breakage of a chain of the electric motor is blocked
Check up presence of short circuit of a chain of the electric motor, the relay and batteries
The lamp burns continuously
Refusal of the block of management
To hand over in repair