Toyota Land Cruiser

FJ60, FJ62 and FJ80 1980-1997 of release

Repair and car operation

Toyota Land Cruiser
+ 1. The maintenance instruction
+ 2. Maintenance service
+ 3. Engines
+ 4. Systems of cooling, heating
+ 5. Fuel and exhaust systems
+ 6. System of decrease in toxicity
+ 7. Transmission
+ 8. Brake system
+ 9. Suspension brackets and a steering
+ 10. A body
- 11. An electric equipment
   11.1. Search of malfunctions
   11.2. Safety locks
   11.3. Fusible crosspieces
   11.4. Breakers
   11.5. The relay
   11.6. The breaker of indexes of turn / of the alarm system
   11.7. A combination of switches on a steering column
   11.8. The lock of ignition and a lock drum
   11.9. Indexes of level of fuel, pressure and oil temperature
   11.10. A guard of devices
   11.11. The screen wiper electric motor
   11.12. The receiver and dynamics
   11.13. The aerial
   11.14. A heater of back glass
   11.15. Headlights
   11.16. The case галогенной headlights
   11.17. A sound signal
   11.18. Replacement of lamps
   11.19. Lateral mirrors with the electric drive
   11.20. Cruise-control system
   11.21. The electric drive window lifterа
   11.22. The electric drive of door-locks
   11.23. Safety pillows
+ 12. Electroschemes

11.5. The relay

THE GENERAL DATA

On considered cars of the relay are included in chains of such consumers as units of fuel system, a starter, antifog headlights, a sound signal. Relays are applied to operated inclusion and switching-off сильноточного the consumer under the influence of an electric signal of low power. Relays are mounted in the uniform block located in a motor compartment, and also in various parts of the car. The relay can be got and checked up, the faulty relay is replaced.

Installation of the relay of an electric equipment of cars FJ60

1. The relay of system of ignition
2. The relay of inclusion of lighting devices
3. The relay of inclusion of back lanterns
4. The relay of the fan of a heater
5. The screen wiper relay
6. The relay of the fan of system of cooling of the engine 7. The breaker of turns
8. The processor of system of decrease in toxicity of exhaust gases
9. The timer of preliminary heating
11. The socket for a portable lamp
12. The processor of seat belts
13. The relay of a control lamp of a charge of the battery
14. The resistor of an alarm lamp

Installation of the relay of an electric equipment of cars FJ62

1. The relay of seat belts
2. The relay of a back heater
3. The relay of a cleaner of a windscreen
4. A breaker
5. The relay of a cleaner of headlights 6. The relay block
7. A combination of devices
8. A tachometre
9. A speedometer
10. Hours

Installation of the relay of an electric equipment of cars FJ80

1. The block of the relay 2
2. The battery
3. A fusible crosspiece (main, АМ1 and АМ2) 4. The block of safety locks
5. The block of the relay 1

Check

PERFORMANCE ORDER

1. The most reliable results are given by check with use of the scheme of inclusion of the relay. If the inclusion scheme is absent, execute checks taking into account following data.

2. The pair of conclusions of any relay is connected to the coil providing operation of the relay. Other conclusions become in pairs isolated or disconnected at запитывании coils.

3. As a rule, distributing of contacts is specified on the relay case.

4. Connect one of conclusions of the coil of the relay to a positive conclusion of the battery through a wire with a thin delay as a safety lock. The second conclusion connect to weight. After connection click should be listened. If click is not present, change polarity of connection (polarity of connection matters on some relays).

5. Check up chain presence between relay conclusions according to marks on the case.

6. If results of checks negative the relay replace.